| Common Name: | LOCTITE LB 8150 SV A/S KNOWN AS SILVER GRADE ANTI-SEIZE LUBRIC, 80209 |
| Manufacturer: | HENKEL |
| SDS Revision Date: | 8/28/2014 |
| SDS Format: | GHS-US |
| Grainger Item Number(s): | 2VFF3 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
HENKEL
SAFETY DATA SHEET
REVISION NUMBER: 004.0
ISSUE DATE: 08/28/2014
| 1. PRODUCT AND COMPANY IDENTIFICATION |  |
PRODUCT NAME:
LOCTITE LB 8150 SV A/S KNOWN AS SILVER GRADE ANTI-SEIZE LUBRIC
IDH NUMBER: 235092
PRODUCT TYPE: LUBRICANT
ITEM NUMBER: 80209
RESTRICTION OF USE: NONE IDENTIFIED
REGION: UNITED STATES
COMPANY ADDRESS:
HENKEL CORPORATION
ONE HENKEL WAY
ROCKY HILL, CONNECTICUT 06067
CONTACT INFORMATION:
TELEPHONE: (860) 571-5100
MEDICAL EMERGENCY PHONE:
POISON CONTROL CENTER: 1-877-671-4608 (TOLL FREE) OR 1-303-592-1711
TRANSPORT EMERGENCY PHONE:
CHEMTREC: 1-800-424-9300 (TOLL FREE) OR 1-703-527-3887
INTERNET: WWW.HENKELNA.COM
| 2. HAZARDS IDENTIFICATION | |
EMERGENCY OVERVIEW:
DANGER:
CAUSES SEVERE SKIN BURNS AND EYE DAMAGE.
HAZARD CLASS HAZARD CATEGORY
SKIN CORROSION 1C
SERIOUS EYE DAMAGE 1
PICTOGRAM(S): CORROSION
PRECAUTIONARY STATEMENTS:
PREVENTION:
DO NOT BREATHE VAPORS, MIST, OR SPRAY. WASH THOROUGHLY AFTER HANDLING. WEAR
PROTECTIVE GLOVES, EYE PROTECTION, AND FACE PROTECTION.
RESPONSE:
IF SWALLOWED: RINSE MOUTH. DO NOT INDUCE VOMITING.
IF ON SKIN (OR HAIR): TAKE OFF IMMEDIATELY ALL CONTAMINATED CLOTHING.
IF INHALED:
REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO REMOVE. CONTINUE RINSING. IMMEDIATELY CALL A POISON
CONTROL CENTER OR PHYSICIAN. WASH CONTAMINATED CLOTHING BEFORE REUSE.
STORAGE: STORE LOCKED UP.
DISPOSAL:
DISPOSE OF CONTENTS AND/OR CONTAINER ACCORDING TO FEDERAL, STATE/PROVINCIAL
AND LOCAL GOVERNMENTAL REGULATIONS.
CLASSIFICATION COMPLIES WITH OSHA HAZARD COMMUNICATION STANDARD (29 CFR
1910.1200) AND IS CONSISTENT WITH THE PROVISIONS OF THE UNITED NATIONS
GLOBALLY HARMONIZED SYSTEM OF CLASSIFICATION AND LABELING OF CHEMICALS
(GHS).
SEE SECTION 11 FOR ADDITIONAL TOXICOLOGICAL INFORMATION.
| 3. COMPOSITION / INFORMATION ON INGREDIENTS | |
HAZARDOUS COMPONENT(S) CAS NUMBER PERCENTAGE*
DISTILLATES (PETROLEUM), 64742-52-5 30 - 60
HYDROTREATED HEAVY
NAPHTHENIC
GRAPHITE 7782-42-5 10 - 30
CALCIUM OXIDE 1305-78-8 10 - 30
PETROLEUM DISTILLATES, 64742-53-6 10 - 30
HYDROTREATED, LIGHT
NAPHTHENIC
ALUMINUM NOT POWDER, DUST OR FUME 7429-90-5 5 - 10
DISTILLATES (PETROLEUM), 64741-44-2 1 - 5
STRAIGHT-RUN MIDDLE
QUARTZ (SiO2) 14808-60-7 0.1 - 1
* EXACT PERCENTAGE IS A TRADE SECRET. CONCENTRATION RANGE IS PROVIDED TO
ASSIST USERS IN PROVIDING APPROPRIATE PROTECTIONS.
| 4. FIRST AID MEASURES | |
INHALATION:
MOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. GET MEDICAL ATTENTION.
SKIN CONTACT:
REMOVE CONTAMINATED CLOTHING AND FOOTWEAR. IMMEDIATELY FLUSH SKIN WITH
PLENTY OF WATER (USING SOAP, IF AVAILABLE). GET MEDICAL ATTENTION. WASH
CLOTHING BEFORE REUSE.
EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. GET
MEDICAL ATTENTION.
INGESTION:
DO NOT INDUCE VOMITING. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON. GET IMMEDIATE MEDICAL ATTENTION.
SYMPTOMS: SEE SECTION 11.
| 5. FIRE FIGHTING MEASURES | |
EXTINGUISHING MEDIA: FOAM, DRY CHEMICAL OR CARBON DIOXIDE.
SPECIAL FIREFIGHTING PROCEDURES:
WEAR SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE CLOTHING, SUCH
AS TURN-OUT GEAR. IN CASE OF FIRE, KEEP CONTAINERS COOL WITH WATER SPRAY.
UNUSUAL FIRE OR EXPLOSION HAZARDS: NONE
HAZARDOUS COMBUSTION PRODUCTS: OXIDES OF CARBON. OXIDES OF NITROGEN.
| 6. ACCIDENTAL RELEASE MEASURES | |
USE PERSONAL PROTECTION RECOMMENDED IN SECTION 8, ISOLATE THE HAZARD AREA
AND DENY ENTRY TO UNNECESSARY AND UNPROTECTED PERSONNEL.
ENVIRONMENTAL PRECAUTIONS:
DO NOT ALLOW PRODUCT TO ENTER SEWER OR WATERWAYS.
CLEAN-UP METHODS:
REFER TO SECTION 8 "EXPOSURE CONTROLS / PERSONAL PROTECTION" PRIOR TO CLEAN
UP. FOR SMALL SPILLS WIPE UP WITH PAPER TOWEL AND PLACE IN CONTAINER FOR
DISPOSAL. FOR LARGE SPILLS ABSORB ONTO INERT ABSORBENT MATERIAL AND PLACE
IN SEALED CONTAINER FOR DISPOSAL.
| 7. HANDLING AND STORAGE | |
HANDLING:
USE ONLY WITH ADEQUATE VENTILATION. PREVENT CONTACT WITH EYES, SKIN AND
CLOTHING. DO NOT BREATHE VAPOR AND MIST. WASH THOROUGHLY AFTER HANDLING.
KEEP CONTAINER CLOSED.
STORAGE: KEEP IN A COOL, WELL VENTILATED AREA.
FOR INFORMATION ON PRODUCT SHELF LIFE CONTACT HENKEL CUSTOMER SERVICE AT
(800) 243-4874.
| 8. EXPOSURE CONTROLS / PERSONAL PROTECTION | |
EMPLOYERS SHOULD COMPLETE AN ASSESSMENT OF ALL WORKPLACES TO DETERMINE THE
NEED FOR, AND SELECTION OF, PROPER EXPOSURE CONTROLS AND PROTECTIVE
EQUIPMENT FOR EACH TASK PERFORMED.
HAZARDOUS COMPONENT(S) ACGIH TLV OSHA PEL AIHA WEEL OTHER
DISTILLATES (PETROLEUM), 5 MG/M3 TWA 5 MG/M3 TWA NONE NONE
HYDROTREATED HEAVY MIST MIST
NAPHTHENIC
10 MG/M3 500 PPM
STEL MIST (2,000 MG/M3)
PEL
5 MG/M3 PEL
MIST.
GRAPHITE 2 MG/M3 TWA 5 MG/M3 PEL NONE NONE
RESPIRABLE RESPIRABLE
FRACTION. FRACTION.
15 MG/M3 PEL
TOTAL DUST.
15 MPPCF TWA
CALCIUM OXIDE 2 MG/M3 TWA 5 MG/M3 PEL NONE NONE
PETROLEUM DISTILLATES, NONE 500 PPM NONE NONE
HYDROTREATED, LIGHT (2,000 MG/M3)
NAPHTHENIC PEL
5 MG/M3 PEL
MIST.
ALUMINUM NOT POWDER, NONE NONE NONE NONE
DUST OR FUME
DISTILLATES (PETROLEUM), 5 MG/M3 TWA 5 MG/M3 TWA NONE NONE
STRAIGHT-RUN MIDDLE MIST MIST
10 MG/M3
STEL MIST
QUARTZ (SiO2) 0.025 MG/M3 2.4 MPPCF TWA NONE NONE
TWA RESPIRABLE.
RESPIRABLE
FRACTION. 0.1 MG/M3 TWA
RESPIRABLE.
0.3 MG/M3 TWA
TOTAL DUST.
ENGINEERING CONTROLS:
PROVIDE ADEQUATE LOCAL EXHAUST VENTILATION TO MAINTAIN WORKER EXPOSURE
BELOW EXPOSURE LIMITS.
RESPIRATORY PROTECTION:
IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW APPLICABLE LIMITS BY
VENTILATION, WEAR A PROPERLY FITTED ORGANIC VAPOR/PARTICULATE RESPIRATOR
APPROVED BY NIOSH. OBSERVE OSHA REGULATIONS FOR RESPIRATOR USE (29 CFR
1910.134).
EYE/FACE PROTECTION:
SAFETY GOGGLES OR SAFETY GLASSES WITH SIDE SHIELDS. SAFETY SHOWERS AND EYE
WASH STATIONS SHOULD BE AVAILABLE.
SKIN PROTECTION: NEOPRENE OR OIL RESISTANT GLOVES.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
PHYSICAL STATE: PASTE
COLOR: SILVER
ODOR: HYDROCARBON-LIKE
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT APPLICABLE
VAPOR PRESSURE: <5 MMHg
BOILING POINT/RANGE: NOT AVAILABLE.
MELTING POINT/RANGE: NOT AVAILABLE.
SPECIFIC GRAVITY: 1.25
VAPOR DENSITY: NOT AVAILABLE.
FLASH POINT: >93 DEG. C (>199.4 DEG. F)
FLAMMABLE/EXPLOSIVE LIMITS - LOWER: NOT AVAILABLE.
FLAMMABLE/EXPLOSIVE LIMITS - UPPER: NOT AVAILABLE.
AUTOIGNITION TEMPERATURE: NOT DETERMINED
EVAPORATION RATE: NOT AVAILABLE.
SOLUBILITY IN WATER: INSOLUBLE
PARTITION COEFFICIENT (N-OCTANOL/WATER): NOT AVAILABLE.
VOC CONTENT: <3%
VISCOSITY: NOT AVAILABLE.
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
| 10. STABILITY AND REACTIVITY | |
STABILITY: STABLE UNDER NORMAL CONDITIONS OF STORAGE AND USE.
HAZARDOUS REACTIONS: WILL NOT OCCUR.
HAZARDOUS DECOMPOSITION PRODUCTS:
IRRITATING ORGANIC VAPOURS. OXIDES OF CARBON. OXIDES OF NITROGEN.
INCOMPATIBLE MATERIALS: STRONG OXIDIZING AGENTS.
REACTIVITY: NOT AVAILABLE.
CONDITIONS TO AVOID:
KEEP AWAY FROM HEAT, IGNITION SOURCES AND INCOMPATIBLE MATERIALS.
| 11. TOXICOLOGICAL INFORMATION | |
RELEVANT ROUTES OF EXPOSURE: SKIN, INHALATION, EYES, INGESTION
POTENTIAL HEALTH EFFECTS/SYMPTOMS:
INHALATION: MAY CAUSE RESPIRATORY TRACT IRRITATION.
SKIN CONTACT: CAUSES SKIN BURNS. MAY CAUSE SKIN IRRITATION.
EYE CONTACT:
CAUSES SERIOUS EYE DAMAGE. THIS PRODUCT MAY CAUSE IRRITATION TO THE EYES.
INGESTION: MAY CAUSE GASTROINTESTINAL DISTURBANCES.
HAZARDOUS COMPONENT(S) LD50S AND LC50S IMMEDIATE AND DELAYED
HEALTH EFFECTS
DISTILLATES (PETROLEUM), NONE IRRITANT
HYDROTREATED HEAVY
NAPHTHENIC
GRAPHITE NONE LUNG
CALCIUM OXIDE NONE IRRITANT, CORROSIVE, EYES
PETROLEUM DISTILLATES, NONE IRRITANT
HYDROTREATED, LIGHT
NAPHTHENIC
ALUMINUM NOT POWDER, NONE CENTRAL NERVOUS SYSTEM,
DUST OR FUME IRRITANT, LUNG
DISTILLATES (PETROLEUM), NONE IRRITANT
STRAIGHT-RUN MIDDLE
QUARTZ (SiO2) NONE IMMUNE SYSTEM, LUNG, SOME
EVIDENCE OF CARCINOGENICITY
HAZARDOUS COMPONENT(S) NTP CARCINOGEN IARC CARCINOGEN OSHA CARCINOGEN
(SPECIFICALLY
REGULATED)
DISTILLATES (PETROLEUM), NO NO NO
HYDROTREATED HEAVY
NAPHTHENIC
GRAPHITE NO NO NO
CALCIUM OXIDE NO NO NO
PETROLEUM DISTILLATES, NO NO NO
HYDROTREATED, LIGHT
NAPHTHENIC
ALUMINUM NOT POWDER, NO NO NO
DUST OR FUME
DISTILLATES (PETROLEUM), NO NO NO
STRAIGHT-RUN MIDDLE
QUARTZ (SiO2) KNOWN TO BE GROUP 1 NO
HUMAN
CARCINOGEN.
| 12. ECOLOGICAL INFORMATION | |
ECOLOGICAL INFORMATION: NOT AVAILABLE.
| 13. DISPOSAL CONSIDERATIONS | |
INFORMATION PROVIDED IS FOR UNUSED PRODUCT ONLY.
RECOMMENDED METHOD OF DISPOSAL:
FOLLOW ALL LOCAL, STATE, FEDERAL AND PROVINCIAL REGULATIONS FOR DISPOSAL.
HAZARDOUS WASTE NUMBER: NOT A RCRA HAZARDOUS WASTE.
| 14. TRANSPORT INFORMATION | |
THE TRANSPORT INFORMATION PROVIDED IN THIS SECTION ONLY APPLIES TO THE
MATERIAL/FORMULATION ITSELF, AND IS NOT SPECIFIC TO ANY
PACKAGE/CONFIGURATION.
U.S. DEPARTMENT OF TRANSPORTATION GROUND (49 CFR):
PROPER SHIPPING NAME: NOT REGULATED
HAZARD CLASS OR DIVISION: NONE
IDENTIFICATION NUMBER: NONE
PACKING GROUP: NONE
INTERNATIONAL AIR TRANSPORTATION (ICAO/IATA):
PROPER SHIPPING NAME: NOT REGULATED
HAZARD CLASS OR DIVISION: NONE
IDENTIFICATION NUMBER: NONE
PACKING GROUP: NONE
WATER TRANSPORTATION (IMO/IMDG):
PROPER SHIPPING NAME: NOT REGULATED
HAZARD CLASS OR DIVISION: NONE
IDENTIFICATION NUMBER: NONE
PACKING GROUP: NONE
| 15. REGULATORY INFORMATION | |
UNITED STATES REGULATORY INFORMATION:
TSCA 8 (B) INVENTORY STATUS:
ALL COMPONENTS ARE LISTED OR ARE EXEMPT FROM LISTING ON THE TOXIC
SUBSTANCES CONTROL ACT INVENTORY.
TSCA 12 (B) EXPORT NOTIFICATION: NONE ABOVE REPORTING DE MINIMIS
CERCLA/SARA SECTION 302 EHS: NONE ABOVE REPORTING DE MINIMIS
CERCLA/SARA SECTION 311/312: IMMEDIATE HEALTH, DELAYED HEALTH
CERCLA/SARA SECTION 313: NONE ABOVE REPORTING DE MINIMIS
CALIFORNIA PROPOSITION 65:
THIS PRODUCT CONTAINS A CHEMICAL KNOWN IN THE STATE OF CALIFORNIA TO CAUSE
CANCER.
CANADA REGULATORY INFORMATION:
CEPA DSL/NDSL STATUS:
ALL COMPONENTS ARE LISTED ON OR ARE EXEMPT FROM LISTING ON THE CANADIAN
DOMESTIC SUBSTANCES LIST.
| 16. OTHER INFORMATION | |
THIS SAFETY DATA SHEET CONTAINS CHANGES FROM THE PREVIOUS VERSION IN
SECTIONS: NEW SAFETY DATA SHEET FORMAT.
PREPARED BY: LOU FABRIZIO, REGULATORY AFFAIRS SPECIALIST
ISSUE DATE: 08/28/2014
DISCLAIMER:
THE DATA CONTAINED HEREIN ARE FURNISHED FOR INFORMATION ONLY AND ARE
BELIEVED TO BE RELIABLE. HOWEVER, HENKEL CORPORATION AND ITS AFFILIATES
("HENKEL") DOES NOT ASSUME RESPONSIBILITY FOR ANY RESULTS OBTAINED BY
PERSONS OVER WHOSE METHODS HENKEL HAS NO CONTROL. IT IS THE USER'S
RESPONSIBILITY TO DETERMINE THE SUITABILITY OF HENKEL'S PRODUCTS OR ANY
PRODUCTION METHODS MENTIONED HEREIN FOR A PARTICULAR PURPOSE, AND TO ADOPT
SUCH PRECAUTIONS AS MAY BE ADVISABLE FOR THE PROTECTION OF PROPERTY AND
PERSONS AGAINST ANY HAZARDS THAT MAY BE INVOLVED IN THE HANDLING AND USE OF
ANY HENKEL'S PRODUCTS. IN LIGHT OF THE FOREGOING, HENKEL SPECIFICALLY
DISCLAIMS ALL WARRANTIES, EXPRESS OR IMPLIED, INCLUDING WARRANTIES OF
MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE, ARISING FROM SALE OR
USE OF HENKEL'S PRODUCTS. HENKEL FURTHER DISCLAIMS ANY LIABILITY FOR
CONSEQUENTIAL OR INCIDENTAL DAMAGES OF ANY KIND, INCLUDING LOST PROFITS.